Product ID:957, INSTANT SCREEN OPENER 15 OZ
MSDS Date:08/16/1990
FSC:6810
NIIN:00N020768
MSDS Number: BZPVM

SPRAYWAY INC

484 VISTA
ADDISON, IL 60101
US

Emergency Phone: 800-228-5635

Info Phone: 708-628-3000

Preparer: PHILIP T MILLER

Cage: 55772

SPRAYWAY INC

ADDISON, IL 60101-4421 US

Telephone: 708-628-3000

Cage: 55772

SOLVENT NAPHTHA (PETROLEUM), LIGHT AROMATIC; (LIGHT

CAS: 64742-95-6

RTECS: WF3400000

Fraction By Weight: 55-65%

OSHA PEL N/K

ACGIH TLV: 50 PPM (MFR)

CYCLOHEXANONE (CERCLA)

CAS: 108-94-1

RTECS: GW1050000

Fraction By Weight: 15-25%

OSHA PEL S, 50 PPM

ACGIH TLV: S, 25 PPM

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

PETROLEUM GAS (LIQUEFIED); (LPG PROPELLANT)

CAS: 68476-85-7

RTECS: SE7545000

Fraction By Weight: 15-25%

OSHA PEL 1000 PPM

ACGIH TLV: 1000 PPM

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ACUTE:INHALATION MAY CAUSE DIZZINESS
AND DROWSINESS. SKIN CONTACT CAN CAUSE REDNESS OR IRRITATION. EYE
CONTACT MAY BE IRRITATING. INGESTION OF AEROSOLS IS NOT A LIKELY
ROUTE, HOWEVER, INGESTION OF LIQ UID MAY RESULT IN VOMITING WHICH
COULD CAUSE ASPIRATION OF PNEUMONITIS. CHRONIC:NONE LISTED BY
MANUFACTURER.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:PRE-EXISTING EYE AND SKIN DISORDERS
MAY BE AGGRAVATED.

First Aid:INHAL:MOVE VICTIM TO SOURCE OF FRESH AIR. CALL PHYS.
EYES:FLUSH IMMED W/WATER FOR @ LEAST 15 MINS. IF IRRIT OCCURS, CONT
PHYS. SKIN:REMOVE CONTAMD CLTHG. WASH SKIN W/SOAP & WATER. WASH
CONTAMD CLTHG B EFORE REUSE. INGEST:DO NOT INDUCE VOMIT. IF VOMIT
OCCURS SPONT, ASPIR (BRTH) OF VOMITUS INTO LUNGS MUST BE AVOID BY
KEEPING VICTIM'S HEAD BELOW HIPS. GET MED ATTN. IMMED! NOTE TO
PHYS:PROD (SUPDAT)

Flash Point Method:TCC
Flash Point:>104F,>40C
Lower Limits:1.8%
Upper Limits:9.2%
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, FOAM.
Fire Fighting Procedures:NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT . CNTNRS SHOULD BE COOLED W/WATER TO PVNT VAP PRESS BUILD
UP.
Unusual Fire/Explosion Hazard:AT ELEVATED TEMPERATURES (OVER 54C-130F)
CONTAINERS MAY VENT, RUPRUTE OR BURST.

Spill Release Procedures:REMOVE ALL SOURCES OF IGNIT & VENTILATE AREA.
SOAK UP W/INERT ABSORB & PLACE INTO DESIGNATED DISP CNTNR. CONSULT
LOCAL REGULATORY AGENCY FOR PROPER DISPOSITION OF MATERIAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:AVOID BREATHING VAPOR. KEEP AWAY FROM
HEAT AND FLAME. USE W/ADEQUATE VENTILATION. DO NOT PUNCTURE/INCIN
CNTNRS.
Other Precautions:PLEAS READ AND FOLLOW DIRECTIONS ON PRODUCT LABEL;
THEY ARE YOUR BEST GUIDE TO USING THIS PROD IN THE MOST EFFECTIVE
WAY, AND GIVE NECESSARY SAFETY PRECAUTIONS TO PROTECT YOUR HEALTH.

Respiratory Protection:NONE REQUIRED IF GOOD VENTILATION IS MAINTAINED.
IF EXPOSURE MAY EXCEED OCCUPATIONAL EXPOSURE LIMITS. (SEE INGRED
SECTION). USE NIOSH/MSHA APPRVD RESP TO PREVENT OVEREXPOSURE.
Ventilation:LOCAL EXHAUST ADEQUATE UNDER NORMAL CONDITIONS. MECHANICAL
(GENERAL):OPTIONAL.
Protective Gloves:CHEMICAL RESISTANT GLOVES.
Eye Protection:ANSI APPRVD CHEM WORKERS GOGGLES .
Other Protective Equipment:WEAR IMPERVIOUS CLTHG TO PVNT SKIN CONT.
ANSI APPRVD EMERGENCY EYE WASH & DELUGE SHOWER .
Work Hygienic Practices:ENSURE STRICT SANITARY CNDTNS ARE CONFORMED TO
WHEN WORKING AROUND CHEM. PROT CLTHG & EQUIP I/A/W 29CFR
1910.132(SUPDAT)
Supplemental Safety and Health
FIRST AID PROC:CNTNS APPROX 65% PETRO DISTILLATE. IF >2.0ML PER KG HAS
BEEN INGESTED & VOMIT HAS NOT OCCURED, EMESIS SHOULD BE INDUCED
W/SUPERVISION. IF SYMPS SUCH AS LOSS OF GAG REFLEX, CONVL/UNCON O
CCUR BEFORE EMESIS, GASTRIC LAVAGE USING CUFFED ENDOTRACHEAL TUBE
SHOULD BE CONSIDERED. HYGIENE PRACT:& CFR 1910.133.

Vapor Pres:110 PSIG
Vapor Density:>1
Spec Gravity:<1 (H*2O=1)
Evaporation Rate & Reference:<1 (ETHER =1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:MISTY SPRAY/CITRUS ODOR.

Stability Indicator/Materials to Avoid:YES
HEAT, FLAME AND STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:(DO NOT STORE ABOVE 54C-130F). KEEP AWAY
FROM HEAT, OPEN FLAMES OR SPARKS. DROPPING OF CNTNRS MAY CAUSE
BURSTING.
Hazardous Decomposition Products:CARBON DIOXIDE, CARBON MONOXIDE AND
ADDITIONAL TOXIC CHEMICALS MAY BE FORMED IN SMALL AMOUNTS.

Waste Disposal Methods:DO NOT PUNCTURE OR INCIN CNTNRS. WHEN CONTENTS
ARE DEPLETED CONTINUE TO DEPRESS BUTTON UNTIL ALL GAS IS EXPELLED.
DISPOSE OF CNTNR I/A/W LOCAL, STATE, AND FEDERAL REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.